MINERALOGY AND ORGANIC MATTER CONTENT OF BOTTOM ASH SAMPLES FROM AGIOS DIMITRIOS POWER PLANT, GREECE

PDF (English)
Publiée : янв. 1, 2004
DOI : https://doi.org/10.12681/bgsg.16673
N. Kantiranis
Department of Mineralogy-Petrology-Economic Geology, School of Geology, Aristotle University of Thessaloniki
Α. Georgakopoulos
Department of Mineralogy-Petrology-Economic Geology, School of Geology, Aristotle University of Thessaloniki
A. Fiiippidis
Department of Mineralogy-Petrology-Economic Geology, School of Geology, Aristotle University of Thessaloniki
A. Drakoulis
Department of Mineralogy-Petrology-Economic Geology, School of Geology, Aristotle University of Thessaloniki
Résumé

Four bottom ash samples from the Power Units of the Agios Dimitrios Power Plant were studied by the method of PXRD to determine their semi-quantitative mineralogical composition. Their organic matter content was calculated by a wet chemical process. Also, the loss on ignition was measured. The samples are constituted mainly of calcite, quartz and feldspars, while micas, clays, gehlenite and portlandite were determined in a few samples in smaller quantities. The amorphous material varied between 10-43 wt. %, while organic matter varied between 5-42 wt. %. Measurements of the loss on ignition overestimate the unburned lignite contents in the bottom ash samples. The management of bottom ashes with high contents of unburned lignite should differ to that of the fly ashes. The oxidation of the inorganic compounds of the unburned lignite may lead to environmental degradation of the landfill areas. Samples showing lower values of organic matter are suitable for a series of uses, such as: snow and ice control, as an aggregate in lightweight concrete masonry units,as a raw feed material for portland cement, as an aggregate in cold mix emulsified asphalt mixes, base or sub-base courses, or in shoulder construction. Systematic study of the unburned lignite of bottom ashes is needed for possible re-combustion.

Article Details
  • Rubrique
  • Energy Resources
Creative Commons License

Ce travail est disponible sous licence Creative Commons Attribution - Pas d’Utilisation Commerciale 4.0 International.

Authors who publish with this journal agree to the following terms:

Authors retain copyright and grant the journal right of first publication with the work simultaneously licensed under a Creative Commons Attribution Non-Commercial License that allows others to share the work with an acknowledgement of the work's authorship and initial publication in this journal.

Authors are able to enter into separate, additional contractual arrangements for the non-exclusive distribution of the journal's published version of the work (e.g. post it to an institutional repository or publish it in a book), with an acknowledgement of its initial publication in this journal. Authors are permitted and encouraged to post their work online (preferably in institutional repositories or on their website) prior to and during the submission process, as it can lead to productive exchanges, as well as earlier and greater citation of published work.

Téléchargements
Les données relatives au téléchargement ne sont pas encore disponibles.
Références
Alexiadis, Α., 1972. Physical and chemical analysis of soil, Thessaloniki, University Publications, 383pp.
American Coal Ash Association, 1996. Coal Combustion By-Product Production and Use: 1966-1994. Alexandria, Virginia.
Baba, Α., 2002. Assessment of radioactive contaminants in by-products from Yatagan (Mugla, Turkey) coal-fired power plant, Environmental Geology 41, 916-921.
Canpolat, F., Yilmaz, K., Kose, M.M., Sümer, M., and Yurdusev, M.A., 2003. Use of zeolite, coal bottom ash and fly ash as replacement materials in cement production, Cementano Concrete Research 23-24,1-5.
Cherial, M., Cavalcante Rocha, J., and Péra, J., 1999. Pozzolanic properties of pulverized coal combustion bottom ash, Cement and Concrete Research 29, 1387-1391.
Filippidis, Α., and Georgakopoulos, Α., 1992. Mineralogical and chemical investigation of fly ash from the Main and Northern lignite fields in Ptolemais, Greece. Fuel 71(4), 373-376.
Filippidis, Α., Georgakopoulos, Α., Kassoli-Fournaraki, Α., 1996. Mineralogical components of some thermally decomposed lignite and lignite ash from the Ptolemais basin, Greece. International Journal of Coal Geology 30,303-314.
Georgakopoulos, Α., Filippidis, Α., Kassoli-Fournaraki, Α., 1994. Morphology and trace element contents of the fly ash from Main and Northern lignite fields, Ptolemais, Greece. Fuel 73(11), 1802-1804.
Goodarzi, F., and Huggins F.E., 2001. Monitoring the species of arsenic, chromium and nickel in milled coal, bottom ash and fly ash from a pulverized coal-fired power plant in western Canada, Journal of Environmental Monitoring 3, 1-6.
Kantiranis, N., Tsirambides, Α., Filippidis, Α., and Christaras, Β., 1999. Technological characteristics of the calcined limestone from Agios Panteleimonas, Macedonia, Greece. Materials & Structures, 32, 546-551
Kantiranis, N., 2001. Calcination study of the crystalline limestone from Agios Panteleimonas, Fiorina, Greece. PhD Thesis, School of Geology, Aristotle University of Thessaloniki, 196 p. (in Greek with extensive English summary).
Kantiranis, N., 2003. Hydration of high-calcium quicklime with methanol-water mixtures. Construction and Building Materials 17, 91-96.
Kantiranis, Ν., Stergiou Α., Filippidis Α., Drakoulis, Α., 2004. Evaluation of the percentage of the amorphous material using PXRD patterns. 10th Int. Congress of the Geological Society of Greece, Thessaloniki, April 14-17, 89-90 (in Greek).
Kolovos, N. Georgakopoulos, A. Filippidis, Α., and Kavouridis, C, 2002. The effects on the mined lignite quality characteristics by the intercalated thin layers of carbonates in Ptolemais Mines, Northern Greece, Energy Sources 24,761 -772.
Kula, I., Olgun, Α., Erdogan, Y., and Sevinc, V., 2001. Effects of colemanite waste, coal bottom ash, and fly ash on the properties of cement, Cement and Concrete Research 31, 491-494.
Oates, J., 1998. Lime and limestone, chemistry and technology, production and uses, Weinheim, Willey-VCH, 455pp.
Rogbeck, J., and Knutz, 1996. Coal bottom ash as light fill material in construction, Waste Management 16, 125-128.
Roth, JA, Debelak, K.A., and Feather, K.F., 1983. Removal rate of zinc from coal bottom ash in aqueous solutions, Water Research 17/9,1139-1143.
Schreurs, J.P.G.M., van der Sloot, H.A., and Hendriks, Ch., 2000. Verification of laboratory-field leaching behavior of coal fly ash and MSWI bottom ash as a road base material, Waste Management 20,193-201.
Sell, N., Mcintosh, T., Severance, C, and Peterson, Α., 1989. The agronomic land spreading of coal bottom ash: Using a regulated solid waste as a resource, Resourses, Conservation and Recycling 2/2,119-129.
Swaine, J.D., 1990. Trace elements in coal, London, Buttrworths.
Targan, S., Olgun, Α., Erdogan, Y., and Sevinc, V., 2002. Effects of supplementary cementing materials on the properties of cement and concrete, Cement and Concrete Research 32,1551-1558.
Targan, §., Olgun, Α., Erdogan, Y., and Sevinc, V., 2003. Influence of natural pozzolan, colemanite ore waste, bottom ash, and fly ash on the properties of Portland cement, Cement and Concrete Research 33, 1175-1182.
Thuß, U., Herzschuh, R., Popp, P., Ehrlich, Chr., and Kalkoff, W.-D., 1997. PCDD/F in flue gas and in bottom ash of lignite domestic combustion and the role of the salt content of the burned briquettes, Chemosphere 34, 1091-1103.
Vlachos, S., and Carrea, Α., 1996. Dry-ash system retrofit improves efficiency of Unit 4 at Ptolemais Power Station, Power Engineering International 4(3), 41-43.
Wang, Y., Ren, D., and Zhao, F., 1999. Comparative leaching experiments for trace elements in raw coal, laboratory ash, fly ash and bottom ash, International Journal oi'Coal Geology 40,103-108.
Ward, CR., 1984. Coal Petrology and coal technology, London, Blackwell.
Zeng, M., and Ksaibati, K., 2003. Evaluation of moisture susceptibility of asphalt mixtures containing bottom ash, Transportation Research Record 1832, 25-3
Articles les plus lus par le même auteur ou la même autrice